TRAFO OIL FAILURE BASED ON DISSOLVED GAS ANALYSIS AND VOLTAGE BREAKDOWN RESULTS
DOI:
https://doi.org/10.26418/telectrical.v1i1.69800Keywords:
Transformer Oil, DGA, BDVAbstract
Contamination on the transformer oil can lead to the oil failure of the transformator. Therefore, the transformer oil needs to be tested to make sure the oil is still in good condition. To find indications of oil failure the transformator needs to be tested DGA and BDV. From the results of the analysis with the TDCG method, the gas content in the transformer oil is less than 720 ppm so according to the IEEE standard, the oil transformer is indicated in normal conditions. In the Key Gas method, the percentage of the dominant carbon monoxide gas content is in the range of 85-90% so it is indicated that heating occurs on paper insulation. In the Duval Triangle method, the cut point between methane gas, ethylene and acetylene is in zone 1 and zone 2 so indicated that the oil of the transformator has thermal interference. In the BDV test, the transformer oil resistance values of 40.43 kV and 38.98 kV were obtained according to the IEC oil standard indicated in normal conditions. Of the four methods used to analyze the condition of the oil transformers concluded the oil of the transformers in a good condition but indicated heating.References
Indonesia, E. (Juni 1998). Particle Discharge and Insulation Material Failure. Accessed on 15 January 2023: from https://www.elektroindonesia.com/elektro/ener13a.html.
SPLN T5.004-3: 2016. Guidelines for Testing the Characteristics of Insulation Oil and DGA Testing. Jakarta: PT PLN (Persero).
AS, N. R., & P, D. (2021). Good Testing on Trafo Oil. Electrical Engineering Studies Program - ISTN, 20-22.
Andayani, N., Simanjutak, Y., & Danial. (2020). Analysis of Water Content and Breakdown Voltage on Isolation of Libra Nutrient Nynas Oil with Variation of Phenol Additives. Journal of Electrical Engineering University of Tanjungpura.
Oktaviani, R., Simanjutak, Y., & Danial. (2020). DGA Test Analysis Using Gas Cromatography Method as Indication of Oil Failure Insulation Transformer GI 150 KV Kotabaru. Journal of Electrical Engineering University of Tanjungpura.
Tohari, M., Sukoco, B., & Haddin, M. (2020). 20KV/150KV Power Transformer Condition Analysis with Dissolved Gas Analysis (DGA) Test Method at PT.PJB PLTU Rembang. Journal of Electrical Engineering of Sultan Agung Islamic University.
Widyastuti, C., & Wisnuaji, R. A. (2019). Transformer oil penetration voltage analysis at PT. PLN (Persero) Bogor. Electronic Scientific Journal: Vol. 11 (II). Hlm. 75-78.
Yudhapraja, S., & Prayogi, A. (2020). Analysis of Transformer Damage Symptoms Based on Dissolved Gas Analysis PLTA Wai Besai Plant. Journal of Research and Evaluation: Vol 1 B14-B21.
Miqdarurri, M. (2016). Isolation failure theory. Accessed on January 18, 2023:from http://eprints.umg.ac.id/197/2/10%20BAB%20II%20TINJAUAN%20PUSTAKA.pdf
Sanjaya, Raga. (2012, 02 Maret). Coolers (Oil/Oil) on transformers, circuit breakers and cables (Ilmu Bahan Semester 1). Accessed on January 18, 2023: from http://mysmpledailylife.blogspot.com/2012/03/pendingin-oilminyak-pada-transformator.html
Jumardin, Ilham, J., & Salim, S. (2019). Study of Nylon Oil Characteristics as an Alternative to Transformer Oil. Jambura Journal of Electrical and Electronics Engineering, 10-11.
Energy Transformers Maintenance Guidelines. PT. PLN (Persero) UP3B West Kalimantan
Syakur, A., & Lazuardi, W. (2019). Application of Roger Ratio, Duval Triangle, Breakdown Test and Water Content Test Interpretation Methods for Diagnosis of Transformer Oil Eligibility. Hlm 63-68.
Misto, & Haryono. (2019). Analysis of dissolved gases on insulated oil as an indicator of power transformer failure with the Dissolved Gas Analysis method. ELKOM, 101-102.
Shidiq, S., Sujatmiko, A., & Paronda, A. H. (n.d.). Pengujian Dissolved Gas Analysis (DGA) Pada Trafo Tenaga 150/20kv 60mva Di Gardu Induk Tambun . JREC, 44-45.
Downloads
Published
Issue
Section
License
Copyright (c) 2023 Telecommunications, Computers, and Electricals Engineering Journal (TELECTRICAL)
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
Authors who publish with this journal agree to the following terms:
- Copyright of the published articles will be transferred to the journal as the publisher of the manuscripts. Therefore, the author confirms that the copyright has been managed by the publisher.
- Publisher of TELECTRICAL is Universitas Tanjungpura.
- The copyright follows Creative Commons Attribution"“ShareAlike License (CC BY SA): This license allows to Share "” copy and redistribute the material in any medium or format, Adapt "” remix, transform, and build upon the material, for any purpose, even commercially.
Telecommunications, Computers, and Electricals Engineering Journal by Universitas Tanjungpura is licensed under CC BY-SA 4.0
